ketoprofen-lysine and Cystic-Fibrosis

Cystic fibrosis (CF) is characterized by a thick, sticky mucus responsible for both airway obstruction and resistance to drug diffusion, reducing the effectiveness of drug delivery to the lung. Studies of drug-mucus interaction may be a crucial step in therapeutic management of CF. In the present research, the effect of a saline solution of sodium bicarbonate (100 mM) on sputum viscosity and the permeation properties of ketoprofen lysinate (Klys) from a previously developed dry powder inhaler were evaluated.. Rheological measurements were performed using an ARES rotational rheometer (Rheometrics, Inc.) with a parallel plate geometry. The gel fraction, separated from the liquid phase of various sputum samples from CF patients was loaded onto the plate. The elastic (G') and the viscous (G") moduli, tan δ (ratio of G" to G') and η* (complex viscosity) were evaluated as frequency-dependent parameters. Drug permeation across CF sputum from dry powders was studied by means of Franz-type vertical diffusion cells. The experiments were conducted on untreated sputum and on sputum treated with bicarbonate.. Rheological studies showed that the elastic modulus (G') was always greater than the viscous modulus (G") and the viscosity decreased with increasing frequency, as for pseudo-plastic fluids. Bicarbonate caused a downward shift of both the elastic and viscous moduli, with a reduction in complex viscosity. As to drug permeation, the untreated sputum slowed down drug dissolution and permeation compared to buffer permeability (control). Permeation studies across CF sputum treated with bicarbonate showed higher Klys dissolution/permeation than untreated sputum.. The interesting results confirm the previously reported bicarbonate. effectiveness in CF; this weak base seems to act by decreasing high viscosity of the CF bronchial secretion and, potentially, resulting in better mucus clearance and in fighting pulmonary infections.

Topics: Administration, Inhalation; Adolescent; Adult; Anti-Inflammatory Agents, Non-Steroidal; Bronchi; Cystic Fibrosis; Dry Powder Inhalers; Elastic Modulus; Female; Humans; Ketoprofen; Lysine; Male; Middle Aged; Models, Biological; Permeability; Rheology; Sodium Bicarbonate; Sputum; Viscosity; Young Adult

Pulmonary inflammation is an important therapeutic target in cystic fibrosis (CF) patients, aiming to limit and delay the lung damage. The purpose of the present research was to produce respirable engineered particles of ketoprofen lysinate, a non-steroidal anti-inflammatory drug able to fight lung inflammatory status by direct administration to the site of action. Micronized drug powders containing leucine as dispersibility enhancer were prepared by co-spray drying the active compound and the excipient from water or hydro-alcoholic feeds. Microparticles were fully characterized in terms of process yield, particle size distribution, morphology and drug content. The ability of the drug to reach the deepest airways after aerosolization of spray-dried formulations was evaluated by Andersen cascade impactor, using the monodose DPI as device. In order to investigate the behaviour of the drug once in contact with lung fluid, an artificial CF mucus was prepared. Drug permeation properties were evaluated interposing the mucus layer between the drug and a synthetic membrane mounted in Franz-type diffusion cells. Finally, the effect of the engineered particles on vitality of human airway epithelial cells of patients homozygous for ΔF 508 CF (CuFi1) was studied and compared to that of raw active compound. Results indicated that powders engineering changed the diameter and shape of the particles, making them suitable for inhalation. The mucus layer in the donor compartment of vertical diffusion cells slowed down drug dissolution and permeation, leucine having no influence. Cell proliferation studies evidenced that the spray drying process together with the addition of leucine reduced the cytotoxic effect of ketoprofen lysine salt as raw material, making the ketoprofen lysinate DPI a very promising product for the inflammation control in CF patients.

Topics: Administration, Inhalation; Anti-Inflammatory Agents, Non-Steroidal; Calorimetry, Differential Scanning; Cell Line; Cell Proliferation; Cystic Fibrosis; Drug Compounding; Drug Design; Dry Powder Inhalers; Humans; Ketoprofen; Leucine; Lysine; Microscopy, Electron, Scanning; Mucus; Particle Size; Powders