harzianolide and butenolide

Direct analysis of microbial cocultures grown on agar media by desorption electrospray ionization mass spectrometry (DESI-MS) is quite challenging. Due to the high gas pressure upon impact with the surface, the desorption mechanism does not allow direct imaging of soft or irregular surfaces. The divots in the agar, created by the high-pressure gas and spray, dramatically change the geometry of the system decreasing the intensity of the signal. In order to overcome this limitation, an imprinting step, in which the chemicals are initially transferred to flat hard surfaces, was coupled to DESI-MS and applied for the first time to fungal cocultures. Note that fungal cocultures are often disadvantageous in direct imaging mass spectrometry. Agar plates of fungi present a complex topography due to the simultaneous presence of dynamic mycelia and spores. One of the most devastating diseases of cocoa trees is caused by fungal phytopathogen Moniliophthora roreri. Strategies for pest management include the application of endophytic fungi, such as Trichoderma harzianum, that act as biocontrol agents by antagonizing M. roreri. However, the complex chemical communication underlying the basis for this phytopathogen-dependent biocontrol is still unknown. In this study, we investigated the metabolic exchange that takes place during the antagonistic interaction between M. roreri and T. harzianum. Using imprint-DESI-MS imaging we annotated the secondary metabolites released when T. harzianum and M. roreri were cultured in isolation and compared these to those produced after 3 weeks of coculture. We identified and localized four phytopathogen-dependent secondary metabolites, including T39 butenolide, harzianolide, and sorbicillinol. In order to verify the reliability of the imprint-DESI-MS imaging data and evaluate the capability of tape imprints to extract fungal metabolites while maintaining their localization, six representative plugs along the entire M. roreri/T. harzianum coculture plate were removed, weighed, extracted, and analyzed by liquid chromatography-high-resolution mass spectrometry (LC-HRMS). Our results not only provide a better understanding of M. roreri-dependent metabolic induction in T. harzianum, but may seed novel directions for the advancement of phytopathogen-dependent biocontrol, including the generation of optimized Trichoderma strains against M. roreri, new biopesticides, and biofertilizers.

Topics: 4-Butyrolactone; Agaricales; Biological Products; Butanes; Coculture Techniques; Cyclohexanones; Lactones; Secondary Metabolism; Spectrometry, Mass, Electrospray Ionization; Trichoderma

Trichoderma harzianum strains T22 and T39 are two micro-organisms used as active agents in a variety of commercial biopesticides and biofertilizers and widely applied amongst field and greenhouse crops. The production, isolation, biological and chemical characterization of the main secondary metabolites produced by these strains are investigated.. Of the three major compounds produced by strain T22, one is a new azaphilone that shows marked in vitro inhibition of Rhizoctonia solani, Pythium ultimum and Gaeumannomyces graminis var. tritici. In turn, filtrates from strain T39 were demonstrated to contain two compounds previously isolated from other T. harzianum strains and a new butenolide. The production of the isolated metabolites was also monitored by liquid chromatography/mass spectrometry during in vitro interaction with R. solani.. This paper reports the isolation and characterization of the main secondary metabolites obtained from culture filtrates of two T. harzianum strains and their production during antagonistic interaction with the pathogen R. solani.. This is the first work on secondary metabolites produced by the commercially applied strains T22 and T39. Our results provide a better understanding of the metabolism of these fungi, which are both widely used as biopesticides and/or biofertilizers in biocontrol.

Topics: 4-Butyrolactone; Anthraquinones; Antibiosis; Ascomycota; Benzopyrans; Fungi; Fungicides, Industrial; Industrial Microbiology; Pigments, Biological; Pythium; Rhizoctonia; Trichoderma